How do I test my club car onboard computer?

Is My Club Car Golf Cart on Board Computer (OBC) Bad?

1. Set the voltage meter to DC Volts 200V.
2. Take voltage from the positive side of the charger port/receptacle to the negative on the battery pack loop of batteries.
3. There should be voltage read on the battery back, this may vary based on the charge.

How do you bypass a club car onboard computer?

To bypass the OBC you will need to connect a 12 gauge black wire from the negative terminal of this battery to where the black wire attaches to the back of the receptacle. That’s it folks; you’re done!

How do I reset my club car computer?

Easily Reset the Club Car Golf Cart OBC

1. Key switch to off.
2. Set forward/reverse to neutral.
3. Put tow/run switch to tow.
4. Disconnect the negative battery terminal from the battery pack.
5. Put the tow/run switch to run.
6. Put forward/reverse switch to reverse.
7. Put key switch to on.

Does my club car have an OBC?

The easiest way to tell is to lift up the seat and look inside the battery area. If your negative wire comes off of the batteries and directly to the motor or anywhere else it does not have an OBC. …

How do you bypass the electric solenoid on a golf cart?

Bypassing Golf Cart Solenoid Method If you do decide to bypass the solenoid, this is what you need to do: Take the two larger wires that connect to the solenoid and connect them directly (keeping all safety precautions in place). This should do the trick and if it does not work then the solenoid is not the problem.

Where is the reset button on a Club Car golf cart?

Identify your main battery supply (usually the largest battery) on your motor. Check around this supply for a small red button that may or may not be labeled “Reset”. Press and hold this button for a few moments and then release it to reset the motor.

Where is the reset button on a Club Car electric golf cart?

How can I speed up my Club Car golf cart?

6 Ways You Can Make a Golf Cart Faster

1. Add More Torque to Your Golf Cart.
2. Upgrade Your Golf Cart’s Motor.
3. Improve the High-Speed Controller of the Cart.
4. Add Better Golf Cart Tires.
5. Use a Higher Powered Golf Cart Battery.
6. Watch the Weight in Your Golf Cart.

What is the OBC on my club car golf cart?

Posted on June 29, 2017January 16, 2019by pete— 107 Comments How To Reset The OBC On My Club Car Golf Cart All Club Car golf carts newer than 1995 have an OBC or ” On Board Computer ” in the charge circuit to monitor and control several functions on the golf cart.

What is the on board computer (OBC)?

What is the On Board Computer (OBC)? Since 1995, 48 volt Club Car’s come with an OBC. The OBC is is a small device that is wired into the golf cart that’s purpose is to regulate the batteries charge.

Why does the OBC turn off the charging?

If the OBC detects a problem in either the charging or drive system, it will shut that feature off. What shouldhappen next! When the fault clears, the OBC is supposed to turn that system back on.